Effects of glucose on the production of recombinant protein C in mammalian cell culture

Effects of glucose on a cultured Chinese hamster ovary cell line producing recombinant human protein C were investigated. After the recombinant cells reached confluency, they were maintained in the medium containing 10% serum and different levels of glucose in either batch or daily-exchange mode. High concentrations of glucose to the cultures yielded higher cell densities. Daily exchanges of media produced higher cell densities than the corresponding batch culture. Total protein C production per cell decreased with time in batch culture, in accordance with the declined glucose metabolism. Supplementation of the media with high levels of glucose diminished both the expression and gamma-carboxylation activities of the recombinant cells. Production of protein C persisted in daily-exchange culture, resulting in a constant production rate of protein C. In this case again, glucose reduced the specific productivity of recombinant protein C. An apparent glucose inhibition constant was determined to be 0.11 mg/mL by Dixon plots. The ability to gamma-carboxylate recombinant protein C was also impaired at the highest level of glucose. From these results, a strategy to maximize recombinant protein C productivity is discussed.     

Suppression of the degradation of recombinant human apolipoprotein E by a protease inhibitor obtained from fetal bovine serum in serum-free culture

The recombinant human apolipoprotein E (Apo-E) produced by Chinese hamster ovary cells (CHO-322 cells) in serum free culture was degraded to 24K and 23K fragments that contained N-terminal amino acid. The degradation site of Apo-E to 24K fragment was between Arg180 and Leu181 and the C-terminal amino acid of 23K fragment was Gly169. In fetal bovine serum (FBS)-containing culture, the degradation was inhibited. However, in calf serum (CS) the inhibitory activity was not detected. Thus, we attempted the purification of the factor with this inhibitory activity from FBS. A protease inhibitor was purified to give a single peak from FBS by ammonium sulfate precipitation and combination of several column chromatographies. When this FBS-derived protease inhibitor (FBS-d-PI) was added to serum-free culture of CHO-322 cells, degradation of recombinant Apo-E to the 24K and 23K fragments was dose-dependently suppressed and accumulation of intact Apo-E in culture supernatant was observed. FBS-d-PI was found to be a glycoprotein with relative molecular size of 75K daltons under reducing condition, and 85K daltons under nonreducing condition by SDS-PAGE. A complex of FBS-d-PI and a cellular protease was also detected in culture supernatant by western blot analysis using mouse monoclonal antibodies against FBS-d-PI.     

Toxoplasma gondii: Purine synthesis and salvage in mutant host cells and parasites

Toxoplasma gondii, growing exponentially in heavily infected mutant Chinese hamster ovary cells that had a defined defect in purine biosynthesis, did not incorporate [U-¹⁴C]glucose or [¹⁴C]formate into the guanine or adenine of nucleic acids. Intracellular parasites therefore must be incapable of synthesizing purines and depend on their host cells for them. Extracellular parasites, which are capable of limited DNA and RNA synthesis, efficiently incorporated adenosine nucleotides, adenosine, inosine, and hypoxanthine into their nucleic acids; adenosine 5′-monophosphate was the best utilized precursor. Extracellular parasites incubated with ATP labeled with ³H in the purine base and ³²P in the α-phosphate incorporated the purine ring 50-fold more efficiently than they did the α-phosphate. Thus, ATP is largely degraded to adenosine before it can be used by T. gondii for nucleic acid synthesis. Two pathways for the conversion of adenosine to nucleotides appear to exist, one involving adenosine kinase, the other hypoxanthine—guanine phosphoribosyl transferase. In adenosine kinase-less mutant parasites, the efficiency of incorporation of ATP or adenosine was reduced by 75%, which indicates the adenosine kinase pathway was predominant. Extracellular parasites incorporated ATP into both the adenine and the guanine of their nucleic acids, so ATP from the host cell could supply the entire purine requirement of T. gondii. However, ATP generated by oxidative phosphorylation in the host cell is not essential for parasites because they grew normally in a cell mutant that was deficient in aerobic respiration and almost completely dependent upon glycolysis.     

Quantification and analysis of reverse mutations at the hgprt locus in Chinese hamster ovary cells

We describe an assay for the quantification of reverse mutations at the hypoxanthine-guanine phosphoribosyltransferase (hgprt) locus in Chinese hamster ovary cells utilizing the selective agent L-azaserine (AS). Conditions are defined in terms of optimal AS concentration, cell density, and phenotypic expression time. After treatment, replicate cultures of 10⁶ cells are allowed a 48-h phenotypic expression time in 100-mm plates. AS (10 μM) is then added directly to the growing culture and AS-resistant (AS^r) cells form visible colonies. This assay is used to quantify ICR-191-, ICR-170-, and N-ethyl-N-nitrosourea-induced reversion of independently isolated HGPRT^? clones. The AS^r phenotype is characterized both physiologically and biochemically. All AS^r clones isolated are stably resistant to AS and aminopterin but sensitive to 6-thioguanine. They also have re-expressed HGPRT enzyme. In addition, several revertants are shown to contain altered HGPRT. The data provide further evidence that ICR-191 and ICR-170 cause structural gene mutations in mammalian cells and also suggest that ICR-191, ICR-170, and N-ethyl-N-nitrosourea induce similar types of mutations in Chinese hamster ovary cells.     

The effect of cessation of growth on protein synthesis in a mutant of Chinese hamster ovary cells with a temperature-sensitive leucyl-tRNA synthetase

A temperature-sensitive mutant of Chinese hamster ovary cells with an altered leucyl-tRNA synthetase fails to grow and to incorporate amino acids into protein properly at or near the non-permissive temperature. This mutant was used to determine whether cessation of growth at the elevated temperature affected elongation factor EF-1, since the activity of EF-1 is markedly lower in non-growing cells in stationary phase than in rapidly-growing cells in exponential phase. Cell-free extracts prepared from cells maintained at 39°C for 24 h showed a marked decrease in the ability to translate natural mRNAs, compared to cells incubated at 34°C. However, the ability to translate poly(U), which requires elongation factor EF-1 (and EF-2), was not affected. Analyses of activities involved in the initiation of protein synthesis and in the activation of amino acids revealed that, with the exception of leucyl-tRNA synthetase, the rest of the components required for translation also appeared to be relatively stable even after 24 h at the elevated temperature. The effects of elevated temperature on cell-free extracts were also investigated. The results were similar to those obtained with intact cells; that is, except for leucyl-tRNA synthetase which was rapidly inactivated in vitro at 39°C, other aminoacyl-tRNA synthetases and translational components involved in chain initiation and elongation were relatively stable. Thus, no change in EF-1 activity was detected as a result of arrested cell growth, an inherent lability of the elongation factor, or metabolic degradation as a consequence of a rapid turnover rate in the absence of protein synthesis.     

Control of passive permeability of chinese hamster ovary cells by external and intracellular ATP

External ATP causes passive permeability change in several transformed cells, but not in untransformed cells. We studied the effect of external ATP on the passive permeability of CHO-K1 cells, a transformed clone of Chinese hamster ovary cells. Treatment of the cells with external ATP alone did not produce a permeability change, and this was observed only when a mitochondrial inhibitor, such as rotenone or oligomycin, was present together with ATP. These inhibitors reduced the concentration of intracellular ATP and a permeability change by external ATP was observed when intracellular ATP was decreased more than 70%. This requirement for permeability change of CHO-K1 cells was quite unique, since passive permeability change of other transformed cells so far tested was induced by ATP alone. Treatment of CHO-K1 cells with cyclic AMP analogues increased their sensitivity to external ATP about 2-fold. The roles of external and intracellular ATP in controlling passive permeability are discussed.     

Human liver aldehyde dehydrogenase in Chinese and Asiatic Indians: Gene deletion and its possible implications in alcohol metabolism

Two separate human liver aldehyde dehydrogenases exist which show differences in substrate specificity, cation inhibition or activation, and molecular weight. In this paper we report a common absence of enzyme 2 in Chinese which may be taken to indicate a gene deletion coding for this enzyme. The possible implication of this gene deletion among Chinese is discussed.     

Effects of metabolic inhibitors on cell lethality and mutation induction in Chinese hamster cells. I. Inhibitors of de novo purine synthesis and a comparison with the effects of caffeine

The effect of pre- and posttreatment incubation of UV-irradiated and ethyl methanesulphonate (EMS) treated cells with non-toxic concentrations of inhibitors of de novo purine synthesis (dnPS) on expression of potentially lethal and premutational damage at the hypoxanthine-guanine phosphoribosyl transferase (HGPRT) locus in V79 cells has been examined. The concentrations of inhibitors used were shown to profoundly perturb de novo DNA synthesis, by measurements of [¹⁴C]formate uptake, and cell cycle progression by flow cytofluorimetry. Postincubation in 6-methyl mercaptopurine ribonucleoside (MMPR) usually but not invariably potentiated the cytotoxic effects of UV and EMS but azaserine (AZS) and methotrexate (MTX) were without effect. No effects on mutant frequencies were observed on posttreatment with any of these agents. Caffeine produced the least effect on dnPS, but invariably potentiated lethal damage. This potentiation of lethal damage is not mediated by dnPS inhibition as has been suggested for Chinese hamster ovary (CHO) cells.